Introducing the Blue Star Hard Top Chest Freezer CHFSD200

The Blue Star Hard Top Chest Freezer CHFSD200 is a powerful and efficient appliance that is perfect for any home or business. With a spacious 200 liter capacity, this freezer is ideal for storing large quantities of food and keeping it at a consistent, safe temperature. The estimated price of the CHFSD200 is around $700, and it is now available for purchase.

Blue Star Detailed Specifications

The Blue Star Hard Top Chest Freezer CHFSD200 features a number of key specifications, including:

200 liter capacity
Manual defrost system
Adjustable thermostat
Recessed handle for easy opening
interior light for easy visibility
Adjustable feet for stability
Lock and key for security
Stainless steel exterior for durability
Reversible door hinge for flexibility

Product Features of Chest Freezer CHFSD200

Robust construction for heavy-duty use
Corrosion resistant body made of pre- coated sheet
Tropicalized for high subcontinental ambiants
High density PUF insulation for better holding time
High energy-efficiency compressor
Spring-loaded hinges for trouble-free opening and closing of lid
Locks in all models
Heavy-duty castors for easy movement
Wide temperature range convertible series - Freezer or Cooler

Installation & Operation

Before the technician arrives, please ensure the following:

There is clear access to the area for new appliance installation and that it will fit into the space.
It is a dry, cool place with good ventilation to enable the appliance to work more efficiently.
There is a proper electrical power point (single phase, 230V; 6 Amp power socket with strong earthing) which should be 2 metres above the floor/ground level.
Someone responsible is at home/shop to sign for the installation.

If the customer is uncertain that the appliance installation can meet the requirements listed above, please do not hesitate to call for discussion on (Toll-free service centre phone 1860 266 6666/1800 209 1177) the problem.

Installation

Blue Star’s dealer technician will carry out the installation of your Chest Freezer. However, for your general information, the following aspects need to be taken care of during installation:

The appliance should be installed at a suitable site, on a good, firm and level surface.
Any floor unevenness should be corrected at the time of installation.
A gap of at least 6 inches (150mm) must be allowed on all sides to facilitate adequate air circulation on all sides of the cabinet.
The appliance is full of fluid/refrigerant that is used to cool it. In transit, it may get shaken around, so it is better to let it settle before it is plugged in.
Leave the appliance stand in the final position for at least 3 hours before switching it on, so that the refrigerant circuit stabilises and no operating problems occur.
The appliance should be connected to a single phase 230V 50Hz AC supply by means of a three-pin plug, suitably earthed. The wires in the mains lead are coloured in accordance with the following code:
Green : Earth Blue/Black : Neutral Red : Phase
It is recommended that the interior of the appliance be cleaned before putting it to use. Lukewarm water containing a little bicarbonate of soda, mixed in the proportion of 1 teaspoonful of bicarbonate to 500ml of water, should be used for the purpose.

Operation of Blue Star Hard Top

The red lamp lights up whenever the appliance is connected to live electricity supply.
The green lamp indicates that the compressor is running or not. It goes off automatically when the temperature inside the cabinet reaches to set point as per thermostat knob setting.
The thermostat can be found on the front side of the appliance.
The thermostat knob can be used to set the desired temperature.

It can be adjusted as per the modes given below:

Freezer mode: From –14°C ± 2°C to –27°C ± 2°C.
Cooler mode: From 5°C to –6°C ± 2°C.

Safety Information

This appliance conforms to current safety requirements. Improper installation, adjustment, alteration, service or maintenance or inappropriate use can, however, lead to personal injury and damage to property.
To avoid the risk of accidents and damage to the appliance, please read these instructions carefully before using it for the first time.
Keep these instructions in a safe place and ensure that other users including new users are familiar with the contents.
Do not modify the power cord length or sharing of outlet with other appliances and don’t replace the power cord with the damaged or unspecified power cord. It will cause electric shock or fire. If the power cord is damaged, it should be replaced by authorised service person as specified by the manufacturer.
Plug in the power socket properly. Loose plug in causes electric shock or fire due to heat generation.
Do not switch ON/OFF the appliance with wet hands. It may cause electric shock.
Use only dedicated power socket for supply to the appliance. Do not use an extension cord; it may cause overloading and intermittent tripping of other appliances or household lights.
Never splash water on your appliance. It may cause short circuit.
In the event of an electrical short circuit, grounding (earthing) reduces the risk of electric shock by providing an escape wire for the electric current. In order to prevent possible electric shock, this appliance must be grounded. Consult a qualified electrician or service person if you have doubts on whether the appliance is properly grounded. Improper use of the grounding plug can result in an electric shock.
Never unplug your appliance by pulling on the power cord. Always grip plug firmly and pull it straight out from the outlet.
When moving your appliance away from the wall, be careful not to roll over the power cord or damage it in any way.
Unplug the power cord from the outlet for cleaning or other requirements. Never touch it with wet hands because you can get an electric shock or be hurt.
Never damage, process, pull out, or twist the power cord, because damage of power cord may cause a fire or electric shock.
Do not place the lit candle within the appliance to de odorise. It may cause explosion or fire.
Do not use or store inflammable materials like ether, benzene, alcohol, medicine, LP gas, spray, cosmetics or aerosol cans with flammable propellant near or in the appliance. It may cause explosion or fire.
When any strange smell or smoke is detected from the appliance, disconnect the power plug immediately and contact the service centre, for it may cause fire.
The appliance should be so positioned that the supply plug is accessible for disconnecting quickly when an unexpected accident happens.
Do not operate any other electrical appliance (e.g. an electric ice cream maker) inside the Chest Freezer.
Do not store cans or bottles containing carbonated drinks or liquids (which could freeze in the freezer mode). The cans or bottles could explode causing injury and damage to the appliance.
The cooler mode is for maintaining the pre-cooled products. This mode is not suitable to perform fast pull down but it can maintain product temperature.
When the ambient temperature and relative humidity are high, there may be frost or water condensed on the appliance. It's a normal phenomenon, please wipe it with the dry towel.
This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety. Children should be supervised to ensure that they do not play with the appliance.
For assistance and/or additional information, contact the authorised service centre, sales & service dealer.

Caution

Before use, the appliance must be placed horizontally and on a levelled base. Only by this way an unimpeded circuit of the refrigerant and optimum function can be ensured.
When your appliance is in operation, do not touch the cold surface in the cabinet, particularly with your hands that are damp or wet. Skin could adhere to these extremely cold surfaces. It may cause frostbite.
Wait for 10 minutes or longer before reconnecting the plug. (It may cause the operation of the appliance to fail.)
Do not install the appliance in a wet place or a place where water or rain splashes. (Deterioration of insulation of electrical parts may cause electrical leakage.)
Deep-frozen ice cream and ice lollies must be eaten only after a few minutes of being taken out from the appliance to avoid injury to lips and tongue (danger of skin detachment).
If you are not using the appliance for an extended period, leave the lid open to prevent odours building up inside. When the appliance lid is open, always set the lock in closed position and keep the key away from small children to prevent accidents.

Technical safety

This appliance contains a small amount of natural refrigerant (R290, R600a), a natural gas that is environment friendly. Though it is flammable, it does not damage the ozone layer and does not increase the greenhouse effect. When transporting and installing the appliance, care should be taken to ensure that no parts of the refrigerating circuits are damaged. Refrigerant squirting out of the pipes could ignite or cause an eye injury. In the event of eye contact with the refrigerant, wash your eyes instantly with plenty of running water and call/consult an eye specialist immediately. If a leak is detected,

avoid any flames or anything which creates a spark,
switch off at the mains and unplug the appliance,
ventilate the room where the appliance is located for several minutes, and
call Blue Star Ltd.

The room must be 1 cubic metre in size for every 8g of R290 or R600a, whichever refrigerant inside the appliance. The amount of refrigerant in your particular appliance is shown on the identification plate. The refrigerant charge quantities are as per international standards. Never start up an appliance showing any sign of damage. If in doubt, consult your dealer. The amount of refrigerant used in the appliance depends upon the size of the room where it will be installed. This can prevent creation of flammable gas and air mixture if a leak in refrigerating circuit occurs.

CHFSD200 Thermostat

Plug in the appliance. Position of the thermostat knob at factory setting# is in freezer mode to maintain –18°C inside the cabinet at standard test condition.

Temperature Selection

The temperature of the thermostat is set as described below:

Cooler mode: When the dial is in cooler position, the temperature inside the cabinet can be adjusted from approximately 5°C to –6°C ± 2°C.
Freezer mode: When the dial is in freezer position, the temperature inside the cabinet can be adjusted from approximately –14°C ± 2°C to –27°C ± 2°C.

Temperature setting must be according to:

ambient temperature of the appliance
quantity of stored food-items
frequency & duration of lid opening

We recommend a factory setting. You will soon learn which is the suitable setting for your requirements.

blue_star_hard_top_chest_freezer_chfsd200.temperature_selection.png

*The figure is indicative; it may vary from actual model #Under standard test conditions, in controlled ambient temperature

Operational DOs & DON’Ts

DOs: (TRUE)

Store only frozen products.
Ensure that there is adequate air circulation on all sides and at the rear of your appliance.
Carefully clean and prepare each item and wrap in polythene or place in waxed cartons.
Keep the size of each package to a minimum. Square packages will utilise space more efficiently.
Switch on the appliance at least 3 hours before operating.
Clean the condenser with a blower every fortnight.

DON’Ts: (FALSE)

Avoid placing unfrozen food items in contact with the food items previously frozen.
Do not load the appliance with fresh produce in front. Frozen food items should be moved to the front, and therefore packages should be carefully labelled.
Do not keep carbonated or any type of drinks in the appliance.
Do not open the lid of the appliance unnecessarily or frequently.
Do not load the appliance without any space. Some air space is necessary around the packs for efficient temperature maintenance.
Do not turn the appliance ‘On’ immediately after turning it ‘Off’; wait for at least 10 minutes.
Do not move the appliance while it is in the ‘On’ state.
Do not keep the appliance near heat sources, below a fan or in direct sunlight.

For the Safety of Customers
If the user/customer smells a gas (in rare case):

Open windows.
Do not touch electrical switches.
Extinguish any open flame.
Immediately call freezer supplier/service centre.

Blue Star Description

Hard Top Chest Freezer CHFSD200 is a high-quality appliance that is built to last. Its stainless steel exterior is both attractive and durable, and the recessed handle makes it easy to open and close. The interior of the freezer is spacious and well-lit, with an adjustable thermostat that allows you to set the perfect temperature for your needs. The manual defrost system ensures that the freezer always operates at peak efficiency, and the adjustable feet make it easy to level the freezer on any surface. The lock and key provide added security, and the reversible door hinge allows you to place the freezer in any location for maximum convenience.

Maintenance of Blue Star Hard Top Chest Freezer CHFSD200

Frosting

Small amount of frost will accumulate inside the appliance, depending upon the frequency and duration of the lid operation or the amount of moisture inside and relative humidity outside. It is essential to ensure that no frost or ice is allowed to form at places where it will affect the close fitting of the lid, which might allow air to penetrate the cabinet, thus encouraging continuous running of the compressor.

Removing frost

Thin frost formation is quite soft and can be removed with a brush or a plastic scraper.

Do not use metal or sharp scrapers which may lead to removal of paint from the surface of the cabinet.
Remove all dislodged frost from the cabinet floor. For the removal of light frost, it is not necessary to switch off the appliance.
For removing heavy ice deposits, the appliance should be completely disconnected from the power supply and emptied.
The contents should be placed in a cardboard box and wrapped in thick blankets or layers of paper to keep them cold.

Cleaning

Clean the inside with warm water mixed with a little bicarbonate of soda and then dry thoroughly.
Wash all removable parts in the same way and reassemble. Do not forget to insert the drain plug.
Clean the condenser with the blower every fortnight.

Defrost Water Drainage Method

There is a water conduit at the bottom of the appliance; when defrosting, pull out the plastic cover; defrosted water will drip into the hole and flow out. (Note: Please keep the plastic cover safe during the defrosting and put it back after defrosting is done.)
Pull out the water conduit by 20-25mm until the water hole can be seen.
Twist the water conduit until the arrow points downward.
After defrosting is done, make sure there is no more water coming out; then put the plastic cover back in place and make the arrow point upward.

Models Description about Chest Freezer

Model No.	SKU DESCRIPTION
CHFSD60DHSW	Chest freezer convertible 60 D series single door stucco inner
CHFSD100DHSW	Chest freezer convertible 100 D series single door stucco inner
CHFSD100DHPW	Chest freezer convertible 100 D series single door PP inner
CHFSD150DHSW	Chest freezer convertible 150 D series single door stucco inner
CHFSD150DHPW	Chest freezer convertible 150 D series single door PP inner
CHFSD200DHSW	Chest freezer convertible 200 D series single door stucco inner
CHFSD200DHPW	Chest freezer convertible 200 D series single door PP inner
CHFSD300DGSW	Chest freezer convertible 300 D series single door stucco inner
CHFSD300DGPW	Chest freezer convertible 300 D series single door PP inner
CHFDD300DGSW	Chest freezer convertible 300 D series double door stucco inner
CHFDD300DGPW	Chest freezer convertible 300 D series double door PP inner
CHFDD700DGPW	Chest freezer convertible 700 D series double door PP inner

Due to continuous product development, colours, features and technical specifications are subject to change without prior notice.

Setup Guide

Setting up the Blue Star Hard Top Chest Freezer CHFSD200 is easy. Simply plug the freezer into a standard electrical outlet and allow it to run for 24 hours before use. This will allow the freezer to reach the optimal temperature and ensure that your food is properly stored. To adjust the temperature, simply turn the thermostat to the desired setting. To defrost the freezer, unplug it and allow the ice to melt naturally. Be sure to wipe down the interior with a clean, damp cloth before replacing your food.

Chest Freezer CHFSD200 Troubleshooting

Symptoms	Possible causes	Suggested remedy
The temperature in your appliance goes to -10°Cor higher	a. The appliance is not turned on	Check power supply and fuse Check indicating lights are glowing
	b. The appliance is overloaded	Remove some contents from appliance
	c. The lid is not closed properly	Checkthere is no thick formation of iceon the sidesof the appliance
	d. The thermostat is not set right	Adjust the thermostat setting
	e. The unit is placed too close to walls	Locate the unit properly
	f. The unit is placed near heat source	Locate the unit properly
	g. The condenser is choked	Clean the condenser
The temperature in your appliance is too low	The thermostat setting is high, towards maximum	Adjust the thermostat at right setting

Note: If you are unable to resolve the problem, please contact the nearest dealer.

Warranty Obligation

Product

Warranty

Parts Covered

Range

(Parts not covered under 4 years of Warranty period)

Chest Freezer CHFSD60DHSW CHFSD100DHSW CHFSD100DHPW CHFSD150DHSW CHFSD150DHPW CHFSD200DHSW CHFSD200DHPW CHFSD300DGSW CHFSD300DGPW CHFDD300DGSW CHFDD300DGPW CHFDD700DGPW

4 years comprehensive warranty

Compressor
Internal Leak
Fan Motor
Thermostat

60 litres to

700 litres

Electrical cable
Bimetal/plastic body/lid
Grilles
Other plastic parts

(All handles,hinges,locks, rubber/glass/plastic parts and lights)

Pros & Cons

Pros

Large capacity
Manual defrost system
Adjustable thermostat
Stainless steel exterior
Lock and key for security

Cons

May be too large for some spaces
Manual defrost system may require more maintenance than automatic defrost

Chest Freezer CHFSD200 Customer Reviews

Customers who have purchased the Blue Star Hard Top Chest Freezer CHFSD200 have praised its spacious capacity and durable construction. However, some have noted that the manual defrost system can be a bit of a hassle, and that the freezer may be too large for some spaces.

Search Manuals in: chfsd60dhsw

Read More